GE Intelligent Platforms CP1A 6U CompactPCI PowerPC Single Board Computer The CP1A 6U CompactPCI single board Features Feature set with AFIX1553 computer (SBC) is the founder member of • Dual channel, dual redundant MIL-STD- • High performance 6U CPCI processor the PowerPact6 family, building on the success 1553B interfaces • Fully rugged – air/conduction cooled of the established PowerPact3 family of 3U • 2x DDC PCI MicroACE • Extensive GE Intelligent Platforms CompactPCI products. • Each channel offers independently software support selectable BC, RT, MT modes The CP1A is based on the proven designs • 64K words of RAM (with parity) per channel of the VME SBCs but takes full advantage • Key features • Transformer-coupled / direct-coupled of the enhanced features of CompactPCI, - PowerPC 7448 such as support for hot swap and much Feature set with AFIX SG - Discovery 3 Integrated System Controller higher I/O pin count. An extensive range In addition to the standard feature set, the of I/O coupled with two PMC sites and AFIX - DDR SDRAM on 133 MHz main AFIX SG offers a combination of SCSI and (Additional Flexible Interface Xtension) memory bus Graphics capabilities. pluggable module make the CP1A the most • 8-bit Ultra SCSI (20 MBs/sec) or 16-bit - 2x Gigabit Ethernet ports versatile single slot solution currently in the Ultra SCSI (40 MBs/sec) (PICMG® 2.16 compliant) defense and aerospace market space. • RGB Analog Graphics (Silicon Motion - 6x serial ports SM722 Graphics Accelerator, with - 5x USB 2.0 ports The PowerPC 7448 processor and Dis- integral 8 MB memory. Resolutions up to covery 3 Integrated System Controller, - 2x PMC sites 1280x1024) combined with industry-leading software - AFIX daughter cards (Note: option with 16-bit Ultra SCSI results in reduced GPIO support and experience in designing and capability from host card - eight lines available) manufacturing rugged electronics for over four decades, give the CP1A the edge in embedded computing performance. Additional Flexible Interface Xtensions (AFIX) For enhanced I/O flexibility the CP1A supports ‘plug-on’ module, which adds rear I/O func- tionality. The Additional Flexible Interface Xtension (AFIX) card is a factory fitted option, providing fully rugged flexibility to the CP1A’s already extensive I/O feature set. Figure 3: CP1A Base Board and AFIX Card Standard Feature Set (without AFIX) • 2x 10/100/1000BaseT Ethernet ports • Keyboard and Mouse • 5x USB 2.0 ports • 17 bits General Purpose I/O from South Bridge (Eight bits capable of generating an interrupt); can be software configured as a parallel port • 16-bits GPIO from PCI bridge • Parallel port • 6x serial ports CP1A 6U CompactPCI PowerPC Single Board Computer Specifications Block Diagram Processor • PowerPC 7448 at up to 1.4 GHz • 1 MB on-chip L2 cache System Controller USB3 • Marvell Discovery III Integrated System Controller COM1 USB4 (ISC) with two PCI-X interfaces COM2 USB5 DDR Temp Flash Main Memory RTC SDRAM 256 MBytes Sensor 512 MBytes • Up to 1 GB DDR SDRAM with ECC • 64-bit data bus running at 133 MHz 7448 Discovery III USB 2 AFIX Flash Memory • 256 MB Flash via a 32-bit data bus at 133 MHz • 16 MB Boot Flash Hot PCI PCI Non-volatile RAM PCI 64 Bit 66 MHz 32 Bit 33 MHz Bridge Bridge Swap • 32 KB AutoStore NVRAM Real-Time Clock GPIO PCI-X 64 to Bit 133 Control PCI • 1 sec resolution South NVRAM J4/J5 MHz & Status UART Bridge Bridge 32 KBytes Ports • 5V standby features alarm interrupts Ethernet Interfaces XD-bus • 2x 10/100/1000BaseT J5 PMC1 PMC2 Serial Ports • 6x RS-232; RS-232/422 or RS-485 66 MHz 64-bit CPCI Keyboard / Mouse • PS/2 compatible J1 J2 J3 J4 J5 USB Ports • 2x USB 2.0 Discrete Digital I/O • Up to 33 bits of TTL-compatible discrete digital I/O • 8 bits capable of generating interrupts Parallel port • 1x Parallel port IEEE P1284 compatible Environmental Level 1 Level 2 Level 3 Level 4 Level 5 Timers Cooling Method Convection Convection Convection Conduction Conduction • 4x 32-bit timer/counters Conformal Coating Optional Standard Standard Standard Standard Watchdog Timer High/Low Temp 0 to 55°C -20 to +65°C -40 to +75°C -40 to +75°C -40 to +85°C • Two available with 1.6 sec time-out Operational (300 ft/m) (300 ft/m) (600 ft/m) At cold wall At cold wall DMA Engines 2 2 2 2 2 • 6x DMA controllers Random Vibration 0.002g/Hz* 0.002g/Hz* 0.04g/Hz** 0.1g/Hz** 0.1g/Hz** CompactPCI Shock 20g*** 20g*** 20g*** 40g*** 40g*** • PCI 6254 Bridge *With a flat response to 1000 Hz, 6 dB/Oct roll-off from 1000 to 2000 Hz ** From 10 to 1000 Hz ***Peak sawtooth 11 ms duration • 33/66 MHz 32/64-bit CPCI interface from PCI to PCI Bridge. Hot swap is supported (PICMG 2.1) Ordering Information PMC • 2x PMC sites (1x PCI-X capable at 133 MHz) Part Number Description • Full 64-pin rear I/O per site CP1A-1100Xx 1.4 GHz PowerPC 6U CPCI SBC, Level 1; 512 MB DDR SDRAM, 256 MB Flash, 2x GbE ports, AFIX Site 2x RS-232, 4x RS-232/422/485 ports, 5x USB 2.0 ports, Mouse and Keyboard, 33 bits GPIO, • AFIX1553 Dual channel dual redundant MIL-STD- 2x PMC slots 1553 interfaces based on DDC MicroAce • AFIXSG Integrated Silicon Motion SM722 graphics CP1A-2100Xx Air-cooled level 2 as above with conformal coating accelerator with 8 MB on-chip memory, plus 8- or CP1A-3100Xx Air-cooled level 3 as above with conformal coating 16-bit Ultra SCSI CP1A-4100Xx Conduction-cooled level 4 as above Power Consumption CP1A-5100Xx Conduction-cooled level 5 as above • 25W X=software option x = AFIX option (0= No AFIX, 1= AFIX1553 single channel, 2= AFIX1553 dual channel, 3= AFIXSG) JTAG Interface • 1x on-board connector Software • Deployed test strategy (BIT and BCS); VxWorks; LynxOS GE Intelligent Platforms Contact Information Americas: 1 800 433 2682 or 1 434 978 5100 Global regional phone numbers are listed by location on our web site at www.ge-ip.com/contact www.ge-ip.com ©2010 GE Intelligent Platforms, Inc. All rights reserved. All other brands or names are property of their respective holders. Specifications are subject to change without notice. 10.10 GFA-1738 PMC1 ETH2 ETH1 COM3/4 MOUSE KEYBOARD COM1/2 GPIO/PARALLEL GPIO COM5/6 AFIX IO AFIX IO USB1 USB2 PMC2