GE Intelligent Platforms CA3 ® High Performance – Low Power 3U CompactPCI Single Board Computer CA3 is a CompactPCI Single Board Computer Ethernet chip that routes one channel Features ® ® (SBC) with an Intel Celeron 650MHz Ultra through a front-panel RJ-45 connector with ® ® • Intel Celeron 650 Ultra Low Low Voltage (ULV) processor in a convection- operation and activity LEDs and a second Voltage processor cooled 3U form factor. channel routed to the rear I/O. • System controller or peripheral card operation The CA3 is designed for embedded The Intel ULV Celeron 650 processor makes • 256 MB SDRAM processing applications using PCI-based the CA3 ideal for power-critical applications. ® 32-bit* architecture. It is based on the same core as he Pentium • 64-bit 100 MHz memory bus processor and is optimized for high • 512 KB boot flash The CA3 includes 256 MB of SDRAM and 512 performance with low power consumption • UltraDMA33 ATA interface KB of boot flash. For increased flexibility, CA3 (+1.1V at 650MHz). includes two serial ports, two USB ports, a • Real-Time Clock with battery back-up parallel port, a front-panel PS/2 keyboard and The dual-mode functionality of the PCI 6254 • Floppy drive interface mouse port, floppy drive interface, and an (formerly the HB6) PCI/PCI Bridge, the CA3 • Two Fast Ethernet ports 10/100 BaseT UltraDMA33 IDE interface for attaching an IDE offers the versatility of operating as a system front-panel RJ-45 connector and rear I/O hard drive or flash disk through the on-board controller or peripheral card. • Two serial ports J4 connector. For network accessibility, the *The CA3 does not support 64-bit backplane. • IEEE 1284 Parallel port CA3 also includes a dual channel 82546EB • Front-panel PS/2 keyboard/mouse port • Two rear I/O USB ports • Front-panel reset button • Front-panel status LEDs • Watchdog, temperature sensors ® CA3 High Performance – Low Power 3U CompactPCI Single Board Computer Ethernet - 82546EB Temperature Specifications • IEEE 802.3 Ethernet 100Base-TX, and • Highest reachable operating temperature depends 10Base-T operation on ambient conditions (airflow) as shown below. All Processor - ULV Celeron 650 values under typical conditions. • Ultra Low Voltage 1.10V @ 650 MHz, 0.95 @ 400 MHz • Dual channel ® • Full-duplex operation • Same core as Intel Pentium III processor Operating Storage • Two independent MAC and PHY functions with common • 16KB L1 data and instruction caches Standard 0°C to +70°C -40°C to +85°C • PCI host interface • 256KB shared L2 cache • Front-panel RJ-45 connector and rear-panel I/O Humidity PCI Bridge - 82443MX100 • Operating: 5 - 95% @ 40°C • 100 MHz, 64-bit system bus Temperature Sensor - MAX6658 • Storage: 5 - 95% @ 40°C • On-board temperature monitoring and processor- • SDRAM controller with 64-bit 100 MHz temperature monitoring memory interface Altitude • Interrupt controller • Operating: 15,000 ft. (4.5 km) JTAG Scan Chain • 32-bit 33MHz PCI bus interface • Storage: 40,000 ft. (12 km) • ULV Celeron 650 (tested separately) • UltraDMA/33 ATA controller • 82549EB Ethernet controller Shock • DMA controller • PCI 6254 PCI/PCI Bridge • C-, I-Style 12g / 6 ms • Three internal timers • XC95144XL CPLD • Real-Time Clock for date and time keeping with battery Vibration back-up and 128-byte SRAM Power Requirements • C-, I-Style 2g rms / 5-100 Hz • Two USB serial ports • +5V, +3.3V Required MTBF • General purpose I/O Power Consumption - Typical current • Calculations TBD in accordance with MIL-HDBK-217, • XBus interface • 15W Typical (20W max.)* please contact the factory • SMBus serial link port *Power values are preliminary estimates Safety Memory - PC100 • All PWBs are manufactured with flammability rating • 256 MB SDRAM of 94V-0 by UL recognized manufacturer • 64-bit 100 MHz memory bus • Rugged design with soldered chips PCI/PCI Bridge - 6254 PCI/PCI Bridge Configuration Matrix • Dual mode operation for system controller and C A 3 X X 2 2 C peripheral card functionality 0 No CompactFlash carrier Flash - 29LV040 • 512 KB 1 Includes CompactFlash carrier site • Hardware selected write protection 0 No CompactFlash Super I/O - FDC37B727 1 64 MB CompactFlash • 8-bit interface • Two NS16C550A-compatible UART serial ports 2 128 MB CompactFlash • Parallel port 3 256 MB CompactFlash • Front-panel PS/2 keyboard and mouse port • Floppy drive controller 1 Reserved • Watchdog timer 2 256 MB DRAM • General purpose I/O 1 Reserved 2 650 MHz C Convection-cooled Grayed options are not offered ® CA3 High Performance – Low Power 3U CompactPCI Single Board Computer Ordering Information Block Diagram Configuration Options See Configuration Matrix Debug Header Accessories Celeron cPCI_J1 (J3) DC/DC +5V +3.3V TM-CA3 I/O Transition Modules XB-CA3-CFIDE UL V Converter Daughter card 650 Processor Operating Systems GE Technologies offers a VxWorks BSP Temp Sensor PCI 6254 PCI/PCI cPCI bus Bridge SDRAM 82443MX100 cPCI_J2 PCI Bridge 82546 Port0 Ethernet Controller Port1 Mem bus J20 SM bus Front Panel FDC37B727 J21 Super I/O PCI local bus PS2 Mouse Xbus PS2 Keybr d COM1 Reset 29L V040 COM2 CPLD Boot Flash Parallel port Digital I/O port USB Port0 USB Port1 TB_IDE J4 FD bus IDE bus GE Intelligent Platforms Contact Information Americas: 1 800 433 2682 or 1 434 978 5100 Global regional phone numbers are listed by location on our web site at www.ge-ip.com/contact www.ge-ip.com ©2010 GE Intelligent Platforms, Inc. All rights reserved. All other brands or names are property of their respective holders. Specifications are subject to change without notice. 01.10 GFA-1397